Off-Grid BOINC research computer proof of concept

Quite some time ago, after a mobile phone upgrade, I hard wired a Buck converter module to the battery terminals of a Samsung Galaxy S7, removed the SIM card, and left it crunching numbers as part of the BOINC project, sat in the corner of the shack powered by the main station PSU. In its steady operating state with no display lit, it consumes about 130mA, which is probably less than the operating current consumed by the big linear PSU powering it!

My plan has always been that my main BOINC contribution should be independent of mains supply, so, after a slight debacle involving a fraudulent sale on ebay of a 100W solar panel with 30A charge controller, which when tested was shown to be a 20W panel and the controller hardly built for 10A, I have a solar panel and charge controller with which to set up a proof of concept... and half my money refunded!

The concept is simple. The BOINC phone and its Buck converter connect to the charge controller load terminals, a 12V 7Ah SLAB to the battery terminals, and the 20W panel to, well, the panel terminals of course! Unfortunately, the only battery of this size I have remaining in an operational state is the one used to power the under stairs lighting! This has been borrowed temporarily. It will be replaced for the time being with a 25Ah beast that just happens to be doing nothing.

The whole lot is in a position where it will receive a decent amount of south facing sun through the day - on my eldest boys windowsill! He wont mind - its already covered in IT and computer parts!

Some tests on the phone showed a peak current at start up of about 450mA, and a steady operational current (computing but display off) of about 130mA. This with a fully charged and 100% capacity 7Ah battery should last several days. At full sun output, the 20W panel should be capable of charging a 7Ah battery in around 5h. So in theory, this set-up should be able to operate 24/7. Of course, this battery is not new and far from peak condition!

If it operates without shutting down in the middle of the night using this battery, then I can have confidence in it operating well with a better 2nd hand unit, which I will have to scrounge up another time!